leaching gold ore thiosulphate

    Sodium Thiosulphate Gold Leaching

    The gold industry has been seeking alternative reagents for leaching gold from low-grade ores for the past 25 years. The cost and transport of cyanide, the poor recovery of gold from carbonaceous ores, the lack of selectivity of cyanide towards copper minerals and the cost of waste treatment are real factors which can make cyanide unattractive in some circumstances. However there are also

    Chat Online

THIOSULPHATE LEACHING AN ALTERNATIVE TO

Thiosulphate leaching is a process that removes gold from gold bearing ores without the use of cyanide. Although not as aggressive a leaching agent as cyanide, thiosulphate offers several technological advantages including its lower toxicity and greater efficiency with gold deposits associated with preg-robbing ores. The thiosulphate leaching

Chat Online
文件大小: 414KB

Gold strike with thiosulphate CSIRO

As part of the thiosulphate process at Goldstrike, gold-bearing ore is heated as a thick slurry of ore, air, water and limestone in large pressure chambers or autoclaves and then pumped into the new ‘resin-in-leach’ circuit that takes place inside large stainless steel tanks.

Chat Online

thiosulfate leaching Gold Refining Forum

May 19, 2011· Has anyone here actually used thiosulfate for leaching gold ore,and had positive results,that can be repeatable as a real leaching process? Has anyone found a real working precipitation process to recover the gold,that works well,and is dependable? Also getting the gold out of the precipitates seems to be a real pain.

Chat Online

Oxidative pre-treatment in thiosulphate leaching of

The acid wash did not dissolve any gold showing that no adsorbed gold complexes were present on the mineral surfaces in the sulphide ore. A gold recovery of 91% was achieved in the direct ammoniacal thiosulphate leaching with 0.25 M thiosulphate, 1 M ammonia and 12 mM cupric ions after 24 h, and 100% gold extraction was obtained at doubled ammonia and thiosulphate concentrations ().

Chat OnlineCited by: 20

Thiosulphate Leaching Mining SGS

Thiosulfate leaching offers a number of benefits related to gold recovery yields and environmental concerns: Thiosulfate leaching of gold ores has great potential to reduce the impact on the environment. Unlike cyanide, which is highly toxic, the chemicals used in the thiosulfate leaching process are benign.

Chat Online

Thiosulfate leaching of gold—A review ScienceDirect

Thiosulfate leaching can be considered a non-toxic process, the gold dissolution rates can be faster than conventional cyanidation and, due to the decreased interference of foreign cations, high gold recoveries can be obtained from the thiosulfate leaching of complex and carbonaceous-type ores. In addition, thiosulfate can be cheaper than cyanide.

Chat OnlineCited by: 491

Ammoniacal thiosulphate leaching of gold ore

The ammoniacal thiosulphate leaching of two gold ore samples namely Akeshi and Hishikari was carried out as a function of time and the results are given in Figure 1a. In this experiment, the thiosulphate and ammonia concentrations were kept at 0.5 and 1M respectively. The solid concentrations of the ores were

Chat Online

(PDF) Ammoniacal thiosulphate leaching of gold ore

In the present study, an attempt is made to assess the feasibility of ammoniacal thiosulphate leaching of gold ore samples from two different mines namely Akeshi and Hishikari of Japan. In this

Chat Online

(PDF) Leaching of OvacIk gold ore with cyanide, thiourea

In the present study, an attempt is made to assess the feasibility of ammoniacal thiosulphate leaching of gold ore samples from two different mines namely Akeshi and Hishikari of Japan.

Chat Online

Barrick Thiosulfate Leaching of Double Refractory Ore

refractory ores which contain only sulfides. In general, the cyanide solution pulls the gold out of the ore and into solution. However, when the standard cyanide leaching solution is used to recover gold from double refractory ores instead of single refractory ores, gold has a strong

Chat Online

Eco-friendly gold leaching Eco-Goldex Reagent

Eco-Goldex O-series ; The O Series (it refers to Ores) is specially formulated and manufactured with the purpose of replacing the toxic sodium cyanide in gold/silver/PGM rock ore leaching. The O series can compete sodium cyanide easily in most rock ore processing including gold leaching rate (similar or even better), agent consumption (similar or slightly higher) and leaching time (similar or

Chat Online

Thiosulphate as an alternative to cyanide for gold

Jul 18, 2013· Thiosulphate is an attractive alternative reagent to cyanide for processing gold ores. It is relatively cheap and non-toxic, forms relatively strong gold and silver complexes, and readily leaches gold ores in ammoniacal solutions, catalysed by Cu(II). It is particularly suited to carbonaceous ores where the recovery of gold by cyanide is poor.

Chat Online

thiosulfate gold leaching micheldeegens

alternative to cyanidation for some gold bearing ore bodies. Whether the leaching is performed in stirred tank reactors or heaps, the size and type of equipment needed for a thiosulphate leaching flowsheet is very similar to a conventional cyanide leach. SGS is a global technical leader in the field of thiosulphate leaching, and our

Chat Online

Gold cyanidation Wikipedia

Gold cyanidation (also known as the cyanide process or the MacArthur-Forrest process) is a hydrometallurgical technique for extracting gold from low-grade ore by converting the gold to a water-soluble coordination complex.It is the most commonly used leaching process for gold extraction.. Production of reagents for mineral processing to recover gold, copper, zinc and silver represents

Chat Online

Cyanide-free gold recovery CSIRO

Aug 02, 2019· Thiosulphate dissolves the fine gold out of ores (the gold that has not recovered by gravity) at similar rates to conventional techniques. It's safe and lowers environmental impacts. The method has undergone intensive testing in the laboratory to understand its leaching performance in association with reagent recovery and recycle.

Chat Online

The treatment of copper-gold ores by ammonium thiosulfate

The application of ammonium thiosulfate for the treatment of copper-gold ores has been investigated. Leaching studies were conducted with copper minerals, copper minerals with gold addition to solution and copper-gold samples of different copper and gold grades. The behaviour of thiosulfate, tetrathionate and sulfate in solution was studied using ion chromatography. The copper sulfide minerals

Chat Online

Effect of additives on thiosulfate leaching of a gold ore

S.J. Dai et al.: Effect of additives on thiosulfate leaching of a gold ore 50 The leaching of sulfide minerals increased with the addition of EDTA, as reflected by the increased sulfur concentration in solution. CMC slightly increased gold recovery at low concentration but hindered gold leaching at a high concentration.

Chat Online

Biooxidation-Thiosulfate Leaching of Refractory Gold

A process of biooxidation followed by thiosulfate leaching of gold from refractory gold concentrate was investigated. Mineralogical studies on the concentrate showed that very fine gold grains (10 μm) were encapsulated in pyrite and arsenopyrite, while the amount of monomer gold was only 21%.The gold-bearing sample was identified as a high-sulfur fine-sized wrapped-type refractory gold

Chat Online

The modes of gold loss in the calcium thiosulfate leaching

The processing of gold is becoming more complicated due to the increasingly complex nature of the remaining gold-bearing ore bodies. This worldwide phenomenon is the driving force for the development of alternative technologies for the leaching and recovery of gold from so-called double refractory ores. Barrick Gold recently commercialized a unique calcium thiosulfate leaching plant to treat

Chat Online

Cyanide-free gold processing technology hits the market

Jun 20, 2019· This trial proved the thiosulphate solution could extract gold from ore at an industrial scale. Following this Clean Mining negotiated exclusive rights to sell and distribute new cyanide-free gold

Chat Online

Gold dissolution in non-ammoniacal thiosulphate solutions

alternative to cyanidation for treating some sulphidic gold ores. Keywords: Thiosulphate, gold oxidation, leaching, electrochemistry, kinetics. Introduction Concern about the environmental impact of the widely used cyanidation technology has generated a lot of interest in searching for an alternative process for gold leaching over the past years.

Chat Online

WO2013152424A1 Chloride process for the leaching of gold

A process for the extraction of gold from a gold-bearing ore or concentrate, comprising the steps of leaching the gold-bearing ore or concentrate with a lixiviant of hydrochloric acid and magnesium chloride at atmospheric pressure at a temperature of at least 90°C and an Eh of at least 900 mV. After a liquid/solids separation step, the solution obtained is subjected to an organic solvent

Chat Online

GOLD LECHING FROM A SAUDI ORE BY THE NONPOLLUTING

Gold leaching from a Saudi ore by the nonpolluting thiosulfate process 63 Fig. 1. Gold dissolution sketch by the ammoniacal thiosulfate process The reaction chemistry using cupric amine as an oxidant can be explained by the intermediate reactions as shown in Eqs. 2 and 3: Au + 5 S 2 O 3 2-+ [Cu(NH 3) 4] 2+ = [Au(S 2 O 3) 2]

Chat Online

Last News

ZhengZhou N-CAI Corporation © 2020 Copyright.Crusher